Ford Explorer recall prompts Transportation Department investigation

Article content

SAN FRANCISCO (AP) — The National Highway Traffic Safety Administration is investigating a Ford Motor Co. recall of more than a quarter-million Explorer SUVs in the U.S. after receiving complaints about repairs intended to prevent the vehicles from unexpectedly rolling away even while placed in park.

Article content

The problem, ascribed to fractures of a rear axle mounting bolt that could lead the drive shaft to disconnect, was addressed by a Ford software update designed to apply the electronic parking brake if the drive shaft failed, the agency said. But according to two complaints from vehicle owners, their SUVs behaved erratically following the repair.

Article content

In one of those cases, the Explorer would reportedly slam to a complete stop at speeds of up to 30 or 40 miles per hour. In the other, it would reportedly lurch into motion while the driver was attempting to disengage the electronic brake. No injuries were reported in these cases, although the first driver reported striking a utility pole when the Explorer started rolling downhill following an abrupt stop, seemingly because the drivetrain was disengaged.

The original recall covered certain 2020 through 2022 Explorers with 2.3-liter engines, as well as 3-liter and 3.3-liter hybrids, and the 3-liter ST. Also included were 2020 and 2021 Explorer Police hybrids and those with 3.3-liter gas engines. Both of the reported incidents involved 2021 Explorers.

A Ford representative said the company is working with the NHTSA on the matter.